Roof Insulation Condensation Problems

It s no surprise that this tends to occur more in colder months when home heating is more common and intense.

Roof insulation condensation problems.

Roof condensation has a very specific cause. Although moisture problems in the roof assembly can be due to waterproofing deficiencies don t neglect the effect of condensation. But with proper design and maintenance principles you don t have to sweat roof condensation issues. It is the leading cause of the deterioration of trusses.

Moisture occurs when heated air inside the home rises up to the roof where it meets the colder temperatures of outside air. In properties 20 to 80 years old condensation can be a potential problem particularly with the recent drive to insulate houses by putting thick layers of thermal insulation in lofts and to reduce air infiltration by stopping draughts. Put the steel down directly on a vapor barrier. That excess moisture ends up as drops of condensation on the roof.

It doesn t matter if the air space is a half inch or six inches because the condensation factor will remain the same. Essentially condensation occurs at night when the temperature inside a building is warmer than outside. Roof condensation occurs when moisture becomes trapped between the roof and the insulation. The rapid cooling leads to immediate condensation.

Suffolk trading standards officers has issued the warning after reports of scam calls to residents from a trader stating that their loft insulation may not meet new government regulations. As it cools it can t hold as much moisture. This applies to both the timber and steel trusses. Our photograph at left shows severe alligatoring on a nearly flat low slope roof that also was relying on tar and roof cement to try to stop parapet wall leaks.

Usually this problem stems from either poor workmanship in installing the roof or insulation insufficient ventilation or excess moisture in the building. The loft insulation means the roof space is colder than before which encourages condensation in the roof. Warm wet air rises and meets the cold roof and cools. In the case of the timber trusses and purlins they will rot and eventually lose their stability.

Metal roof over shingles condensation metal roofs must be laid flat on a vapor barrier because steel will condensate if there s any air space underneath it. This is another major problem which is starting to affect more homes as the government word gets around and our nasty insulation companies are promoting free insulation paid for by the taxpayer. Flat roofs and low slope roofs also face potentially serious condensation problems that can in turn lead to costly rot or mold damage in buildings. Do your research check the claims the insulation companies make.

Picture a cloud of moisture floating overhead between the rafters.